Transient Gas-liquid Flow in Helical Axial Pump Diffuser and Its DMD Analysis
Abstract
In order to analyze the unsteady characteristics of helical axial pump, numerical simulation of unsteady gas-liquid two phase flow in helical axial pump was carried out, and the flow field distributions of different blade heights at different flow rates were obtained. Dynamic modal decomposition (DMD) was used to decompose the transient velocity field under the condition of flow rate of 100m3/h and gas content of 30%. The first four major modes and their corresponding frequency information were obtained which can reflect the main flow characteristics. The characteristics of flow field in diffuser can be divided into dissipative modal, basic static modal and high order dynamic modal. The dissipative modal attenuated gradually with time and had little influence on the development of the flow field. The basic mode was the steady-state characteristic with a frequency of 0, which reflected the characteristics of steady state flow field caused by flow passage. The order three and order four dynamic modes reflected the rotor-stator interaction between impeller and diffuser. It gradually dissipated in the process of continuous downstream development of diffuser, and the effect of rotor-stator interaction on downstream flow of guide blade was small. The main modal field characteristics and frequency information were obtained by decomposing the phase field. The characteristics of the basic static modal field showed that on a section with a large guide blade height, the higher the velocity was, the lower the gas content was. The dynamic modal characteristics of the phase field were basically consistent with those of the velocity field. The DMD method can clearly analyze the complex transient flow characteristics in the guide vane of helical axial pump.
Keywords: helical axial pump, transient flow, two-phase flow, dynamic modal decomposition
Download Full Text:
PDFReferences
MACK S, STUART S. Multiphase pumping as an alternative to conventional separation pumping and compression[ С ] //34th Annual PSIG Meeting, Portland, USA, 2002.
ZHANG Jinya, CAI Sliujie, LI Yongjiang, et al. Visualization study of gas-liquid two-phase flow patterns inside a three-stage rotodynamic multiphase pump [J]. Experimental Thermal and Fluid Science, 2016, 70:125 - 138.
ZHANG Jinya, CAI Shujie, ZHU Hongwu, et al. Experimental investigation of the flow at the entrance of a rotodynamic multiphase pump by visualization[ J ]. Journal of Petroleum Science and Engineering, 2015, 126:254 -261.
ZHANG Jinya, LI Yongjiang, CAI Shujie, et al. Investigation of gas-liquid two-phase flow in a three-stage roto dynamic multiphase pump via numerical simulation and visualization experiment [J]. Advances in Mechanical Engineering, 2016, 8(4) :1 - 13.
ZHANG Jinya, CAI Shujie, ZHU Hongwu, et al. Numerical investigation of compessible flow in a three-stage helicoaxial multiphase pump[ J/OL]. Transactions of the Chinese Society for Agricultural Machinery, 2014, 45(9) :89 -95. http:// www. j-csam.org/jcsam/ch/reader/view_abstract. aspx? flag = l&file_no = 20140915&joumal_id = jcsam. D0I: 10. 6041/j. issn. 1000-1298.2014.09.015. (in Chinese)
YU Zhiyi, ZHU Baoshan, CAO Shuliang. Interphase force analysis for air-water bubbly flow in a multiphase rotody-namic pump [J]. Engineering Computations, 2015, 32(7) ;2166 -2180.
YU Zhiyi, LIU Ying. Characteristic analysis of unsteady gas liquid two phase flow in a multiphase rotodynamic pump[ J/OL] . Transactions of the Chinese Society for Agricultural Machinery, 2013 , 44 ( 5 ) : 66 - 69. http: // www. j-csam. org/jcsam/ch/ reader/view_abstract. aspx? flag = l&file_no = 20130513&journal_id = jcsam. DOI: 10. 6041/j. issn. 1000-1298. 2013. 05. 013.( in Chinese)
LIU Ming, TAN Lei, CAO Shuliang. Design method of controllable blades angle and orthogonal optimization of press rise for a multiphase pump [ J]. Energies ,2018 ,11 ( 5 ) ;1048.
ZHANG Wenwu, YU Zhiyi, ZAHID M N, et al. Study of the gas distribution in a multiphase rotodynamic pump based on interphase force analysis[J]. Energies ,2018 ,1 1 ( 5 ) :1069.
SERENA A, BAKKEN L E. Flow visualization of unsteady and transient phenomena in a mixed-flow multiphase pump [C]// Proceedings of the ASME Turbo Expo, 2016; 13 - 17 .
ZHANG Jinsong, TAN Lei. Energy performanceand pressure fluctuation of a multiphase pump with different gas volume fractions [ J ]. Energies, 2018 ,1 1(5) : 1216.
KOU Jiaqing, ZHANG Weiwei. Dynamic mode decomposition and its applications in fluid dynamics[J]. Acta Aerodynamica Sinica,2018, 36(2 ): 163 - 179. (in Chinese)
WEI Jiavun, LI Weipeng, XU Siwei, et al. Analysi of mechanism of slat low frequency noise based on zonal DMD[J]. Acta Aeronautica et Astronautica Sinica, 2018, 39 ( 1 ) ;182 - 192. (in Chinese)
TONG Fuling, LI Xinliang, DU AN Yanhui. Dynamic mode decomposition of shock wave and supersonic boundary layer interactions in a compression ramp[ JJ. Acta Aeronautica et Astronautica Sinica, 2017, 38( 12) ;81 -92. ( in Chinese)
WANG Jianming, W ANG Han, GUI Lin. Dynamic mode decomposition of tip clearance flow in a compressor cascade [ J ]. Journal of Propulsion Technology, 2018, 39(3) : 520 -527. (in Chinese)
HU Zhi, LIU Pengyin, ZHU Xiaocheng, et al. DMD analysis of airfoil * s flow field under different degrees of dynamic stal [J]. Journal of Engineering for Thermal Energy Power, 2017, 32(7) :52 -57,138. (in Chinese)
SCHMID P J. Dynamic mode decomposition of numerical and experimental data [J ]. Journal of Fluid Mechanics,2010, 656 ( 10) : 5 -28.
SCHMID P J. Application of the dynamic mode decomposition to experimental date[J]. Experiment in Fluids,2011 , 50(4) ; 1123 - 1130.
HU Chenxing, DING Jie, ZHU Xiaocheng, et al. Dynamic mode decomposition of unsteady flow filed in a volute of centrifugal compressor [ J ]. Journal of Shanghai Jiaotong University, 2018, 52(9) :40 -45. (in Chinese)
HONG Shuli, HUANG Guoping, LU Weiyu, et al. Coherent structures of cascade under different attack angles with DMD method [J ]. Journal of Aerospace Power, 2018, 33(9) ;111 - 121. (in Chinese)
Refbacks
- There are currently no refbacks.
